Search results
Results from the WOW.Com Content Network
Inside the wastegate actuator, a spring acts to open the wastegate, and oil pressure acts to close the wastegate. On the oil output side of the wastegate actuator sits the density controller, an air-controlled oil valve which senses upper deck pressure and controls how fast oil can bleed from the wastegate actuator back to the engine. As the ...
Regardless of the effectiveness of the boost controller, wastegate actuator springs that are too soft can cause the wastegate to open before desired. This due to the exhaust gas backpressure pushing against the wastegate valve itself, causing the valve to open of the actuator at all. Therefore, there is an upper limit to the effectiveness of a ...
This design has a lower flow rate compared to VNT types so a wastegate may be incorporated with this design. [5] VGTs may be controlled by a membrane vacuum actuator, electric servo, 3-phase electric actuation, hydraulic actuator, or pneumatic actuator using air brake pressure. Unlike fixed-geometry turbines, VGTs do not require a wastegate. [6]
Basic charging pressure shall be 0,40 ±0,03 bar (5,80 ±0,43 PSI). After adjustment the push rod must have at least two turns (2 mm) pre tension when connecting to the waste gate lever. The purpose with that is to make sure that the waste gate is held close when not affected.
Wastegate control and anti-lag; Theft prevention by blocking ignition, in response to input from an immobiliser; In a camless piston engine (an experimental design not currently used in any production vehicles), the ECU has continuous control of when each of the intake and exhaust valves are opened and by how much. [3] [4]
The turbo included with the VG20ET had two different settings. At low speeds, the turbo's wastegate would stay closed improving the response at low rpm. At high speeds, the flap would stay open, decreasing resistance and increasing exhaust flow. At its maximum flow, the flap would open at an angle of 27 degrees, while the A/R ranged from 0.21 ...
The Trionic 8 is an advanced engine management system in the Trionic series, created by Saab Automobile.It is used in both Saab 9-3 and Opel Vectra vehicles, and is available with 150, 175 and 210 horsepower (160 kW) engines.
And that this statement: "The wastegate will open further as the boost pressure pushes against the force of the spring in the wastegate actuator until equilibrium is obtained." be changed to: "The wastegate will open further as force resulting from the boost pressure counteracts the force of the spring in the wastegate actuator.