Search results
Results from the WOW.Com Content Network
The development of modern portland cement (sometimes called ordinary or normal portland cement) began in 1756, when John Smeaton experimented with combinations of different limestones and additives, including trass and pozzolanas, intended for the construction of a lighthouse, [3] now known as Smeaton's Tower.
(A) Cement; 1. Specification for 33,43,53 Grade ordinary Portland cement IS 269 - 2015 2. Specification for Rapid hardening Portland cement IS 8041 - 1990 3. Specification for Portland Pozzolona cement IS 1489 (part 1&2) 1991 4. Methods of physical test for hydraulic cement IS 4031 - 1988 5. Method of chemical analysis of hydraulic cement IS ...
A 25% strength gain between 7 and 28 days is often observed with 100% OPC (ordinary Portland cement) mixtures, and between 25% and 40% strength gain can be realized with the inclusion of pozzolans such as flyash, and supplementary cementitious materials (SCMs) such as slag cement.
It requires a much lower content in colored impurities in the raw materials (essentially limestone and clay) used to produce clinker: low levels of Cr 2 O 3, Mn 2 O 3, and Fe 2 O 3), but above all, a higher temperature is needed for the final sintering step in the cement kiln (1600 to 1700 °C in place of 1450 °C for ordinary Portland cement ...
The resulting hard substance, called 'clinker', is then ground with a small amount of gypsum (CaSO 4 ·2H 2 O) into a powder to make ordinary Portland cement, the most commonly used type of cement (often referred to as OPC). Portland cement is a basic ingredient of concrete, mortar, and most non-specialty grout. The most common use for Portland ...
Geopolymer cement is an alternative to ordinary Portland cement and is used to produce Geopolymer concrete by adding regular aggregates to a geopolymer cement slurry. It is made from inorganic aluminosilicate (Al-Si) polymer compounds that can utilise recycled industrial waste (e.g. fly ash , blast furnace slag ) as the manufacturing inputs ...
Portland cement clinker (abbreviated k in the European norms) is ground to a fine powder and used as the binder in many cement products. A small amount of gypsum (less than 5 wt.%) must be added to avoid the flash setting of the tricalcium aluminate (Ca 3 Al 2 O 6 ), the most reactive mineral phase (exothermic hydration reaction) in Portland ...
The use of GGBS in addition to Portland cement in concrete in Europe is covered in the concrete standard EN 206:2013. This standard establishes two categories of additions to concrete along with ordinary Portland cement: nearly inert additions (Type I) and pozzolanic or latent hydraulic additions (Type II). GGBS cement falls in the latter category.