Search results
Results from the WOW.Com Content Network
A bubble column reactor is a chemical reactor that belongs to the general class of multiphase reactors, which consists of three main categories: trickle bed reactor (fixed or packed bed), fluidized bed reactor, and bubble column reactor. [1] A bubble column reactor is a very simple device consisting of a vertical vessel filled with water with a ...
Commercial systems typically use a bubble column reactor, where air is bubbled through a vertical column that is liquid full of the hot and pressurized wastewater. Fresh wastewater enters the bottom of the column and oxidized wastewater exits the top. The heat released during the oxidation is used to maintain the operating temperature.
Biological methanation in a pressurized reactor vessel (in-situ process). Pressure allows for better hydrogen solubility and therefore easier conversion into methane by microorganisms. [10] A possible reactor configuration can be Autogenerative high-pressure digestion. Research in Korea has demonstrated that 90% > CH4, 180 MJ/m3 biogas can be ...
An example of a bubble cap tray that could be found inside of a stripping column. Stripping is mainly conducted in trayed towers (plate columns) and packed columns, and less often in spray towers, bubble columns, and centrifugal contactors. [2] Trayed towers consist of a vertical column with liquid flowing in the top and out the bottom.
Vertical bubble columns, a project at the Universidad EAFIT to utilize algae to reduce CO 2 emissions. A bubble column photo reactor consists of vertically arranged cylindrical columns made out of transparent material. The introduction of gas takes place at the bottom of the column and causes a turbulent stream to enable an optimum gas exchange.
The circulating catalyst process can be replaced by fluid-bed technology. Early experiments with cobalt catalyst particles suspended in oil have been performed by Fischer. The bubble column reactor with a powdered iron slurry catalyst and a CO-rich syngas was particularly developed to pilot plant scale by Kölbel at the Rheinpreuben Company in ...
The typical McCabe–Thiele diagram in Figure 1 uses a q-line representing a partially vaporized feed. Example q-line slopes are presented in Figure 2. The number of steps between the operating lines and the equilibrium line represents the number of theoretical plates (or equilibrium stages) required for the distillation.
Ebullated bed reactors are a type of fluidized bed reactor that utilizes ebullition, or bubbling, to achieve appropriate distribution of reactants and catalysts.The ebullated-bed technology utilizes a three-phase reactor (liquid, vapor, and catalyst), and is most applicable for exothermic reactions and for feedstocks which are difficult to process in fixed-bed or plug flow reactors due to high ...